© 2014 American Chemical Society. Photocurrent spectroscopy is used to measure both the charge transfer and exciton optical absorption spectra of various bulk heterojunction organic solar cells. The energy difference between the polymer HOMO energy and the fullerene LUMO energy is obtained from the spectra, along with the disorder energy. Combining information from cells with several different polymers and fullerenes allows measurements of the energy differences between HOMO or LUMO energies for about 10 different polymers and fullerenes, with an estimated uncertainty of 50 meV. Heterojunction band offsets are obtained for the various cells, distinguishing between the excitonic and the single-carrier band offsets. The cell open-circuit voltage is shown to be closely correlated with the interface band gap. The exciton disorder energy is directly correlated to the band-tail disorder and we also consider the effects of exciton thermalization on the charge generation mechanism. The data indicate that an energy offset between the polymer exciton and the charge transfer ground state below about 0.25 eV adversely affects the cell performance, while a HOMO band offset below about 0.2-0.3 eV also degrades cell performance but by a different mechanism.

This study explores the influence of electronic and ionic conductivities on the behavior of conjugated polymer binders through the measurement of entropic potential and heat generation in an operating lithium-ion battery. Specifically, the traditional poly(vinylidene fluoride) (PVDF) binder in LiNi0.8Co0.15Al0.05O2 (NCA) cathode electrodes was replaced with semiconducting polymer binders based on poly(3,4-propylenedioxythiophene). Two conjugated polymers were explored: one is a homopolymer with all aliphatic side chains, and the other is a copolymer with both aliphatic and ethylene oxide side chains. We have shown previously that both polymers have high electronic conductivity in the potential range of NCA redox, but the copolymer has a higher ionic conductivity and a slightly lower electronic conductivity. Entropic potential measurements during battery cycling revealed consistent trends during delithiation for all of the binders, indicating that the binders did not modify the expected NCA solid solution deintercalation process. The entropic signature of polymer doping to form the conductive state could be clearly observed at potentials below NCA oxidation, however. Operando isothermal calorimetric measurements showed that the conductive binders resulted in less Joule heating compared to PVDF and that the net electrical energy was entirely dissipated as heat. In a comparison of the two conjugated polymer binders, the heat dissipation was lower for the homopolymer binder at lower C-rates, suggesting that electronic conductivity rather than ionic conductivity was the most important for reducing Joule heating at lower rates, but that ionic conductivity became more important at higher rates.